Yarmouth Boat Yard Outboard Service
Yarmouth Boat Yard Service Center is a full service outboard repair facility where factory-trained and certified technicians perform anything from simple tune ups to re-powers. Simple maintenance or repair work done now will save you from costly repairs in the future. To complete the Winterization and Storage Contract simply download the form, then open the Adobe PDF, complete and submit. Or download, complete and save then send to service@ybyboats.com.
Customer Forms
Thinking about purchasing a new motor?
Give us a call and we can walk you through what will fit your boat best.
SPRING COMMISSIONING
- Shrink Wrap Removal
- Topside Cleaning
- Topside Detailing
- Launch Boat
- Launch with Hydraulic Trailer
- Lift boat or Set Back on Trailer
- Clean & Wax Hull
- Compound & Wax Hull
- Safety Equipment Check
- Fill Gas/Diesel Tanks
- Sea Trial
- Bottom Paint
- Add Epoxy Barrier Coating
- Strip Existing Bottom Paint
- Battery Installation
- Commission Air Conditioning
- Air Conditioning Maintenance
- Commission Refrigeration
- Commission Water Systems
- Replace Water Filter Cartridge
- Trim Tab Maintenance
- Commission Generator
- Generator Preventative Maintenance
- Vacuflush Preventive Maintenance
- Vacuflush Vent Filter Replacement
- Basic Mechanical Commissioning
- Engine Tune Up
- Computer Diagnostic Service
- Replace Anodes
- Remove and Replace Water Pump Impeller
- Remove, Clean and Replace Thermostat
- Oil and Filter Change
- Replace Primary Fuel Filters
- Replace High Pressure Fuel Filters
- Compression Test
- Replace Spark Plug Wires
- Recondition Props
- Skeg Reconditioning
- Propeller Shaft Straightening
- Trailer Check and Lube
- Service Power Winch
- Fill and Bleed Brake Fluid Actuator
- Inspect Brake Pads
- Clean, Inspect and Pack Bearings
- Trailer storage
WINTERIZATION & PREVENTIVE MAINTENANCE
- Spray Engine & Electrical w/Corrosion Inhibitor Drain & Fill Lower Unit
- Remove & Inspect Prop - Clean & Grease Shaft - Check for Line
- Grease Steering & Engine Fittings as Required
- Treat Fuel on Board & Run through the Engine
- Flush Cooling System with Fresh Water
- Clean & Lubricate Throttle & Shift Linkage
- Run Fogging Oil through Engine
- Spray Engine & Electrical w/Corrosion Inhibitor
- Replace Fuel Filters
- Replace Engine Zincs as Needed
- Change Oil & Filter if applicable
- Engine Scan if applicable ($80 value included)
GENERAL SERVICE
- Change Engine Oil & Filter
- Engine Tune-Up
- 10 hr. Service Check
- 20 hr. Service Check
- 100 hr. Service Check
- Steering Cable
- Check Electrical System
- Adjust Throttle Shifter
- Change Transmission Oil
- Bilge Pump Repair
- Lubricate Trailer Bearings
- Rack and Pinion Stering
- Replace Upholstery and Canvas
- Fix Seat Slider
Questions?
Call us at (207) 846-9050, email service@ybyboats.com, or click below.